aashto specifications for crushed stone as backfill materials

210 Structure Backfill. Furnish materials consisting of either sand-sized particles or sand-sized particles mixed with gravel, crushed gravel, or crushed stone. Do not use crushed concrete or reclaimed asphalt. (2) Ensure that the material provided has a liquid limit less than or equal to 25 and a plasticity index less than or equal to 6. Read More

Mine backfill

Crushed salt is the most used backfill material in salt mines. With particle diameter less than about 60 mm initial porosity obtained by pneumatic backfilling is in the order of 35 %. A long-term stable backfill for potash mines with MgCl brines is the so-called Sorel-con-crete or MgO-concrete, based on Mg-Si-hydrates (see also Walling and Provis, 2022). 50 45 40 35 30 25 …

Crushed Concrete in Petersfield, Crushed Concrete in

Backfill Material; Shoulder Stone; To Manufacture Fresh Concrete; To Create Recycled Stone Used for Site Stabilisation; One of the main benefits of using recycled, crushed concrete is that it is easy to transport, place and compact according to the different kinds of applications. The fact that it is an excellent substitute for conventional concrete makes it a popular material of …

Using 3/4" minus or similar material for backfill

 · What would be a drawback of using recycled (crushed concrete/asphalt) 3/4" minus material for back filling foundations I would think it would self compact decently enough- better than topsoil not quite as good as sand, it drains well, and it has plenty of voids in it so freezing water wont move it around so much, and it's inexpensive- $ yd around here for …

Backfilling in Foundation : Types and Procedure

Use an excavator to fill in twelve inches of mixed materials on the sides of the area. After which, compress the soil and stone using the rolling compactor. You must repeat the same backfill procedure until the entire area is completely filled. Filling should be done in layers, each layer being of 15cm to 20cm.


 · Use of RCG in Concrete. Concrete Footpath Field Trial with Crushed Glass and Recycled Plastic, Victoria; RCG in Concrete Footpath Field Trials in Cairns, Queensland; RCG in Concrete Pavements in Woolgoolga to Ballina Pacific Highway Upgrade Project, New; South Wales; RCG in Concrete Pavements, Waverley Council, …

In situ disposal of crushed concrete waste as void fill

 · Preparation of crushed concrete samples. For each of the four samples of crushed concrete obtained, –2 kg sub-samples were randomly taken from the bulk (∼25 kg) sample to be used for laboratory experiments and dried at 40 °C overnight to remove moisture prior to fractionating using test sieves of 20 mm, mm and mm.


B. Utility Backfill Materials: 1. Concrete sand 2. Gem sand 3. Pea gravel 4. Crushed stone 5. Crushed concrete 6. Bank run sand 7. Select backfill 8. Random backfill C. Material Handling and Quality Control Requirements. DEFINITIONS A. Unsuitable Material: 1. Materials classified as ML, CL-ML, MH, PT, OH, and OL according to ASTM D2487. 2. Materials that …

What should I backfill my retaining wall with?

 · This should be a clean crushed rock, like a #57 or #78 stone, 3/4″ crushed rock, or clean crushed limestone. What should I backfill my retaining wall with? – Related Questions Can you put dirt behind retaining wall? Behind any retaining wall should be a thick layer of dry drainage material that separates the wall from soil. Backfill can be made with gravel, stones …

Pros and Cons of backfilling foundation with gravel

builder wants to backfill with the existing dirt from the excavation, but I told him to use gravel or crushed stone instead of the high clay content soil to better promote drainage. Are there any drawbacks in going the gravel route. I'm assuming the builder is just taking the cheapeast way out so he doesn't have to pay to haul away the excavated dirt. Ponyboy 2022-07-21 02:31:05 …

17070/Trenching & Backfilling for Piping Systems

BACKFILL MATERIAL A. Except where a 1:10 cement/sand or flowable fill concrete mix is required (See Section 02745), granular soil backfill materials shall be utilized. Suitable backfill material shall be clean, shall not be expansive nor have high organic content, shall be free of clay, marl, unstable materials, debris, lumps and clods, and shall meet the following requirements: 1


Backfill material shall be free from organic materi al and conform to one of the following types: .1 Type 1 – Granular Backfill Sieve Size % Passing Standard Sieve Granular Limestone mm 100 100 85 – 100 85 – 100 mm 25 – 80 25 – 80 425 mm 15 – 40 15 – 35 75 µm 8 – 18 0 - 10 Min. Crush Count 15% - Max. Los Angeles Abrasion Loss 40% 32% Max. Shale …

Strength and stiffness of compacted crushed concrete

 · In Japan and many other countries, a great amount of crushed concrete aggregate (CCA) is being and will be produced by demolishing old and/or out-of-service concrete structures. The use of CCA as the backfill of soil structures, such as embankments and retaining walls, replacing costly selected natural backfill soil (, well-graded gravelly soil) is highly required. …

backfill crushed concrete do not use

backfill crushed concrete do not use Nov 07, 2022 Recycling crushed concrete to be reused helps reduce landfill crowding AND saves more resources from being used to create new concrete. Old concrete can be crushed down to specific sizes, cleaned so that unwanted debris is removed from the mixture, and reused as a solution to a number of construction and …

Crushed Concrete

Crushed Concrete. Size: 75mm to 0mm. Usage: Crushed Concrete is perfect for creating a hardstanding area, haulage road or any other sub base use such as piling mats or general backfill. Because this product is recycled, not only is it economical to reuse demolition waste it is also considerably cheaper than primary alternatives such as Type 1.

How Much Does Crushed Concrete Cost?

 · 67 is fit for use as a backfill behind retaining walls. 304, which has been crushed to -inch minus, may be left exposed as it is or placed under concrete or asphalt. 311 is suitable for use as pipe bedding or for general filling. Lastly, number two is around two inches to three inches in diameter and is suitable for use as a main base under the crushed aggregate. …

Section 3010

The Engineer may authorize the use of crushed PCC for pipe sizes up to 12 inches. 4. Use aggregates having a percentage of wear, Grading A or B, not exceeding 50%, determined according to AASHTO T 96. SUDAS Standard Specifications Division 3 - Trench and Trenchless Construction Section 3010 - Trench Excavation and Backfill 5 Revised: 2022 Edition …

Taking Down the Brick Wall

 · Contractors often crush and screen asphalt or concrete generated from their work to create a product they can use as backfill or foundation for buildings or roads. The denseness of concrete and asphalt make these materials well-suited to these applications. While the practical uses of recycled asphalt and concrete are well established, the significantly lower …

uses for crushed concrete inbackfill of wall

How to Backfill Concrete Garden Guides. How to Backfill Concrete By Larry Simmons ; Updated September 21, 2022 Backfilling concrete is the process of pushing crushed rock and topsoil against a concrete foundation wall or slab to fill in the space left around the concrete that allowed for proper pouring of the material.

What is crushed aggregate base?

 · The crushed aggregate base lays on heavy traffic or driveways areas. Dense Aggregate Base. Dense-graded base course are aggregates having different particular size. Recycled aggregates in concrete can also be of use. They form a dense layer having stones and minimum amount of voids. They are primarily in use when construction and pavement

backfill crushed concrete do not use

Potential use of recycled asphalt pavement and crushed concrete as backfill for mechanically stabilized earth walls Viyanant, Chirayus (2022) Now showing. Read More. Foundation Drains GreenBuildingAdvisor Secondly, referring to drawings 1-05002 Concrete basement//insulation out// use filter fabric to separate the crushed stone from the backfill. In. Read More. …

210 Structure Backfill

particles or sand-sized particles mixed with gravel, crushed gravel, or crushed stone. Do not use crushed concrete or reclaimed asphalt. (2) Ensure that the material provided has a liquid limit less than or equal to 25 and a plasticity index less than or equal to 6. The contractor may substitute type A for type B material. Gradation


Crushed Glass is used for pipe and trench backfill, used to backfill foundations and garages before pouring concrete, used in replacement of sand or peagravel for construction applications. Recycled crushed glass is a WADOT specification materials. Two years ago The Olympian interviewed . John and Diana Specht, the owners of Concrete Recyclers:

209 Granular Backfill

particles or sand-sized particles mixed with gravel, crushed gravel, or crushed stone. Do not use crushed concrete or reclaimed asphalt. (2) Ensure that the material provided has a liquid limit less than or equal to 25 and a plasticity index less than or equal to 6. The contractor may substitute grade 1 for grade 2 material. Gradation

Drainage Aggregates

Crushed concrete is recycled concrete that comes in graded and screened sizes for use as a hard fill or drainage aggregate. Versatile. Atlas Concrete can supply a range of products to suit any application, for a drainage medium under a driveway, to backfill behind block walls and drainage around storm water and sewer lines. Great drainage material. In any situation …


 · RECYCLED ASPHALT PAVEMENT AND CRUSHED CONCRETE BACKFILL: STATE-OF-THE-ART REVIEW AND MATERIAL CHARACTERIZATION. This report describes research results from the first year of a three-year study focused on the use of recycled asphalt pavement (RAP) and crushed concrete (CC) as backfill for mechanically stabilized earth …

Concrete vs crushed gravel for fence posts in clay soil

 · I'm prepping to build a fence in the back yard and am going back and forth between using crushed gravel and concrete. I've read lots of differing opinions on the pros and cons of each. I'm leaning towards using crushed gravel as it's easier to repair posts if they rot. I'm just worried that with clay soil it will just fill with water and stay there for days. I'm not 100% sure …

7 Different Crushed Stone Sizes and Their Applications

 · Most use this material to create pavers and concrete blocks. Specialty Crushed Stone #57 – This category refers to a stone that is about 3/4 inch long. Most typically use it for concrete mix, landscaping, and drainage. #67 – Crushed stone #67 includes stone that is 3/4 inch or smaller in size. #67 is a great material for road and slab base as well as fill. If you are …


  • Miftahul Jannat

    Provide a sample analysis report, and conduct a feasibility study and analysis based on the local environmental topography.

  • Eleanor Fant

    The entire team tactfully delivered a project of exceptional quality while staying on schedule & under budget.

  • Philippe Jenvrin

    We have been using it for a period of time, the quality of the product is very good, we will consider working together again.

Write a comment


Production Area


Senior Production Manager


junior & senior technicians


large production bases